巩义市华升机械厂
公司简介
我厂位于连霍高速巩义东出口处，东约500米。是生产各种薯类产品的厂家。我厂生产的薯类淀粉加工设备，具有经久耐用、动力小、效率高，省电、省力、用人少，生产加工成本低，对县、乡、村集体和个人都适用。多年来，我厂产品畅销全国各地，深受广大用户好评。
Company profile
I plant is located in Lianhuo highway Gongyi east exit, about 500 meters east. Is the production of various potato products manufacturers. The potato starch processing equipment produced by our factory has the advantages of durability, small power, high efficiency, power saving, labor-saving, less employing, and low production and processing cost, which is applicable to the county, township, village collective and individual. Over the years, our products sell well all over the country and are well received by the majority of users.
红薯磨浆淀粉机 土豆淀粉加工设备 家用地瓜浆渣分离机
主要应用于薯类淀粉、马铃薯全粉等成套生产线中的原料（物料）清洗。该机采用逆流洗涤原理，物料（薯类）从进口流入清洗机滚笼内随螺旋绞条至出口，而清洗槽内的水，在滚笼内螺旋绞条的反作用向清洗机进口，与物料（薯类）逆向运动，清洗效果好，可除泥、除砂。
洗薯机,可将鲜薯清洗、提升、输送至淀粉机
Sweet potato starch grinding m achine potato starch processing equipment household sweet potato pulp residue separator
It is m ainly used in cleaning raw m aterials (m aterials) of potato starch, potato powder and other complete production lines. The m achine adopts the principle of counter current washing. The m aterial (potato) flows into the roller cage of the cleaning m achine from the inlet and goes to the outlet along with the spiral sliver. The water in the cleaning tank, in the roller cage, reacts with the spiral twisted strip to the inlet of the cleaning m achine and moves in reverse direction with the m aterial (potato). The cleaning effect is good, which can remove mud and sand.
Potato washing m achine can clean, lift and transport fresh potatoes to starch m achine
薯通过一定斜度的清洗沟槽流送，在清洗沟槽中红薯被水浸泡附着在表面的相当一部分大块泥土脱落，之后红薯被送人清洗机内，经过2次或3次清洗后，被送人下一道工序或通过倾斜式输送带输送到贮存料斗中备用。引进成套设备中清洗工艺采用2台或3台板式清洗机串联。清洗机主要的优点是，能满足设计要求，清洗效果较好，清洗后，可以进行连续生产，能够使设备尺寸缩小，结构简单，耗水量少，使红薯的破损率降低等。
生产各种洗薯机,红薯洗薯机,土豆洗薯机,红薯清洗机,土豆清洗机,螺旋清洗机。
清洗机由机架、主轴、滚笼、螺旋绞条、清洗槽及传动件组成，整机结构精简，设计合理，运行平，物料破碎率低，节能节水。
The sweet potato flows through the cleaning groove with a certain slope. In the cleaning groove, the sweet potato is soaked in water, and a considerable part of the large soil attached to the s u r f a c e falls off. After the sweet potato is washed twice or three times, it is sent to the next process or transported to the storage hopper by the inclined conveyor belt for standby. Two or three plate type cleaning m achines are used in series in the imported complete set of equipment. The m ain advantages of the cleaning m achine are that it can meet the design requirements, and the cleaning effect is good. After cleaning, it can carry out continuous production, reduce the size of the equipment, s i m p l e structure, less water consumption, and reduce the da m age rate of sweet potato.
Production of a variety of potato washing m achine, sweet potato washing m achine, potato washing m achine, sweet potato cleaning m achine, potato cleaning m achine, screw cleaning m achine.
The cleaning m achine is composed of fra me, m ain shaft, rolling cage, spiral twisted bar, cleaning groove and transmission parts. The whole m achine has the advantages of s i m p l e structure, reasonable design, smooth operation, low m aterial crushing rate, energy saving and water saving.
红薯淀粉分离机改变了手工生产淀粉时因氧化造成的淀粉光彩变差、变暗的现象;加工过程中被破碎打垮的粉渣在显微镜下呈丝状，有利于淀粉从纤维上游离出来，因此进一步提高了淀粉的提取率。
淀粉机性能和技术参数：
1、全封闭机体，无漏水、漏渣、漏浆现象.
2、整机稳定性能好，噪音低。
3、可一次完成渣、浆分离，淀粉纯净，渣内不含渣皮、渣块、丁状物。
4、节约耗材，自动进薯、破碎、分离、排浆、排渣。
5、刺辊带水工作，缩短了渣粉浆空气中的氧化反应，提高淀粉纯白度。
6、浆渣分离度98以上，残渣含粉率2左右.
Sweet potato starch separator changes the phenomenon that starch luster becomes poor and darkens due to oxidation when starch is produced by hand; the broken powder residue in the processing process is filiform under the microscope, which is conducive to the starch dissociation from the fiber, so the extraction rate of starch is further improved.
Perform ance and technical para meters of starch m achine:
1. Fully enclosed body, no water leakage, slag leakage, slurry leakage
2. The whole m achine has good stability and low noise.
3. It can complete the separation of slag and pulp at one time, the starch is pure, and there is no slag skin, slag block and sm all substance in the slag.
4. Saving consum ables, aut o m atic feeding, crushing, separation, slurry discharge, slag discharge.
5. The air oxidation reaction of slag slurry was shortened and the whiteness of starch was improved.
6. The separation degree of pulp and slag is above 98 and the powder content of residue is about 2
